Farm Talk

Crops

October 29, 2013

Grain bin safety costs little, saves a lot

Parsons, Kansas — It costs less than $500 to make it safer to enter farm grain bins, says a University of Missouri Extension rural safety and health specialist.

"You can't afford not to follow safe procedures," says Karen Funkenbusch as the harvest season approaches. While $500 may sound like a lot, the savings are priceless, she says.

Entering grain bins is dangerous, and farm safety experts say grain producers should develop a "zero entry" mentality. "Stay out of the bin," Funkenbusch says. "But if you must enter, do not go alone. Grain entrapment is one of the least understood hazards in today's family farm operations."

There are simple, inexpensive safety techniques that can help avoid grain bin fatalities.

First, turn off and disconnect or lock out all power equipment such as augers.

"With today's high-capacity loading and unloading systems, people are helpless in flowing grain within seconds," she said. The cost for a lockout kit to prevent this is about $100. The savings are priceless.

"Entrapment by flowing grain can be prevented by restricting access to the grain. Use locks on bin doors and hatches to present unauthorized access," she added. And adults should enforce a policy of not allowing riding or playing in grain wagons or other transport vehicles.

Second, use a body harness with an anchored lifeline when entering from a level at or above stored grain. The harness costs and $250 and 100 feet of rope costs about $100. Savings are priceless.

"Research shows that rescuing someone from grain is not easy," Funkenbusch says. "The force ranges from 325 pounds for an average 165-pound person buried in hip-deep grain, to more than 1,500 pounds to rescue the same person who's 3 feet under the grain surface!" Running fans to aerate grain before entering will help improve ventilation, at small cost per kilowatt-hour. "Never walk on or down the grain to make it flow," she said. Grain may become crusted on top and might look stable, but the "bridge" might be formed over a large air pocket that will serve as a deadly tunnel in which a person can be sucked into and suffocated within seconds. It costs only seconds to think about safety. The cost for a few extra kilowatts is small; the savings are priceless.

"Have a trained observer outside the bin," she said. This person can act as a contact with the person inside the bin and can call for help if needed. The cost, depending on the hourly wage, probably is less than $10. Again, the savings are priceless.

"Confirm that all safety precautions are in place," she said. "Always avoid entering a grain storage bin if at all possible, but if you must, follow safe procedures. You can't afford not to," Funkenbusch said. What if there is an accident? Funkenbusch recommends the following:

•Shut off all unloading equipment.

•Call 911.

•Stop anyone from entering the scene until trained emergency personnel arrive.

•If the bin has an aeration blower, turn it on to increase the airflow through the bin to help the entrapped person breathe.

•Assemble equipment such as front-end loaders, shovels, plywood for cofferdams and portable augers for assistance with a rescue.

•If you should become trapped in a grain bin or silo, stay near the outer wall and keep moving. If necessary, you can walk until the bin is empty or the flow stops.

For more information review MU Extension guide "Safe Storage and Handling of Grain" available at extension.missouri.edu/p/G1969. £

1
Text Only
Crops
  • wheat_freeze_lodging.jpg Freeze could damage some Kan. wheat

    The hard freeze throughout Kansas in the early morning hours of April 15, could cause some damage to wheat, said Jim Shroyer, K-State Research and Extension crop production specialist. Wheat in the jointing stage is most at risk, he said.

    April 22, 2014 1 Photo

  • cornplantlatemay2.jpg WASDE report eases low crop price fears

    USDA’s April 9 World Agricultural Supply and Demand Estimates continued a series of recent reports that have offered corn and soybean producers a more optimistic grain-price outlook than what was expected for most of the winter, Purdue Extension agricultural economist Chris Hurt says.

    April 15, 2014 1 Photo

  • USDA: Corn acres expected to drop 4%

    The amount of American cropland devoted to corn is expected to shrink about 4 percent this year as farmers devote more acres to soybeans, the U.S. Department of Agriculture said last week.

    April 8, 2014

  • Bt-resistant rootworms ID’d in five states

    Researchers say bugs are developing resistance to the widely popular genetically engineered corn plants that make their own insecticide, so farmers may have to make changes.

    April 1, 2014

  • MU economist: Corn, bean price volatility next 5 years

    Expect volatility in the soybean and corn markets over the next five years, said Pat Westhoff, director of the University of Missouri Food and Agricultural Policy Research Institute (MU FAPRI).
    Look for corn prices to drop to $4 per bushel and soybean to $10 per bushel on average for the next five years, he said.

    March 25, 2014

  • marestail.jpg Plan now to control marestail in soybeans

    Controlling marestail in soybeans has been a big challenge for Kansas no-till producers in recent years.
    Because soybeans are generally planted later in the season, and marestail generally germinates in the fall or early spring, application timing and weed size are critical factors to successful control.

    March 18, 2014 1 Photo

  • Checking alfalfa for winter injury

    In the last couple of weeks, I’ve heard many concerns about alfalfa production for this spring.
    Cold temperatures and lack of snow cover are the two main issues producers are worried about for next season’s crop production, as certainly the alfalfa plant could die if exposed to extremely cold temperatures. In general, alfalfa plants can tolerate up to three weeks of winter injury before the plants are killed.

    March 11, 2014

  • soypods.jpg USDA reports on status of GE crops

    Genetically engineered (GE) varieties with pest management traits became commercially available for major crops in 1996.
    More than 15 years later, adoption of these varieties by U.S. farmers is widespread and U.S. consumers eat many products derived from GE crops — including corn-meal, oils, and sugars — largely unaware that these products were derived from GE crops.

    March 4, 2014 1 Photo

  • wheat-head.jpg Everest still leads Kan. wheat acres

    For the second year in a row, a variety of wheat developed by Kansas State University, is the leading variety in Kansas.

    February 25, 2014 1 Photo

  • RickReimer.jpg Innovation, exports fuel soybean demand

    Brent Hayek is revved up about potential new uses for soybeans, and he is piling up the miles to share his enthusiasm.

    February 18, 2014 2 Photos

Hyperlocal Search
Premier Guide
Find a business

Walking Fingers
Maps, Menus, Store hours, Coupons, and more...
Premier Guide
Seasonal Content